Kubota RTV1140 Parts

When looking for parts, its is often a good idea to try and obtain a copy of a pdf manual as well.

When buying parts for the Kubota RTV1140, it is a good idea if possible to have the chassis number of the vehicle, as well as being able to be as specific as possible as to which part is actually required.

This will help to track the part, and also help in locating a manual if needed which will contain diagrams for Kubota RTV1140 parts, and greatly help in being able to fit them properly.

Replacement parts made by another manufacturer are normally referred to as aftermarket parts. Aftermarket parts should perform the same function as a standard manufacturer part, but will normally be cheaper.

If the Kubota RTV1140 is still under warranty, then it is likely to be part of the warranty conditions that manufacturer parts are used. A number of people also prefer manufacturer parts because there are specifically designed to be used with the appropriate rtv.

Below is a breakdown of the main areas and categories of parts used in most Kubota rtv’s. It is really important to check the specific item needed prior to purchase, especially if bought online.

Kubota RTV1140 Parts category

Batteries

Kubota batteries use the most current technology to make sure there are sufficient and powerful as possible. These normally include a negative plate paste expander, and a sodium sulphate additive.

Belts

Kubota belts are claimed to last up to 3 times longer than comparable aftermarket products.

In addition, they are made in what is called an alignment line, allowing the courts to equalise the energy distribution flow. This results in a more stable tension. In addition, they contain fiber enforced rubber that helps support the integrity of the belt

Kubota RTV1140 Filters

Engine oil filters

An oil filter is meant to help reduce or eliminate any potentially damaging element may be produced by the engine oil to date the activity

Hydraulic filters

A Kubota hydraulic filter is designed to do a similar job to an engine oil filter, but the hydraulic system, thereby protecting valves and hydrostatic transmission parts, which are an integral part of keeping the rtv operating safely and efficiently

Other types of filters include a suction filter, an HST filter, a fuel filter and an outer air filter.

Kubota RTV1140 Lubricants

Hydraulic oil – kubota super universal trans-hydraulic fluid
Kubota UDT Fluid
Kubota Excavator Hydraulic Oils
Engine Oil
Gear Oil
Grease
Brake Fluid

Paints

Linkage Accessories

Clevises
Trailer Jacks
Topwind Jacks
RTV grab hook
Sidewind Jacks
Forged Top Links
Lift Arms and lift Arm Parts
Stabilizer Arms

Kubota RTV1140 Workshop Tools

Radios and observation kits
RTV accessories
Lubrication
Fuel and oil equipment
Chemicals
Cargo control
Chains – safety chains, tire chains, tow chains
Lift equipment
Shop products
Diagnostic tools
Safety products
Sprayers
Tool storage
Battery charging
Moisture testers

Keyless Start System

Net Wrap and Twine

Kubota illustrated parts list

Quick reference parts look up and illustrated parts look up

The main Kubota website has a facility allowing people to quickly look up what parts may be needed for their Kubota RTV1140

Series
Model
Engine model

Kubota RTV Parts Online Catalogue

Kubota RTV1140 Manual PDF

The operator and service manual for the Kubota RTV1140 is most easily accessed as a PDF document, and can be downloaded either from the main Kubota website, or from a number of other websites online, either as a free download or normally at a minimal cost

The manual is a crucial document in terms of advising both how to operate the rtv in a safe and efficient way, and at the same time keeping its operating parts running smoothly and effectively as possible

The Kubota parts diagrams that are part of the manual are important in helping anyone to fit or repair a replacement part, either as part of a routine service, or because the part has become defective.

The Kubota RTV1140 PDF manual has a number of sections, which would normally cover the following areas of operation and servicing.

Safe operation of vehicle

Servicing of vehicle

Specifications

Instrument panel and controls

Engine operation

Starting the engine
Coldweather starting
Block heater
Stopping the engine
Warming up
Jumpstarting

Vehicle operation

Starting, headlight switch
Hazard light switch
Work light (front)
Worklight (rear)
Brake pedal
Range gear shift lever
Parking brake lever
Speed control panel
Stopping
Checks during driving
Fuel gauge
Coolant temperature gauge
Parking
Accessories
12 V electric outletthis

Operating techniques

Differential lock
Directions for use of power steering
Unfamiliar terrain
Driving in reverse
Driving in four-wheel-drive
Turning the vehicle
Hills
Traversing hillsides
Sliding and skidding
Driving through water
Operating hand throttle
Stationery hydraulic outlet

Cargo bed

General caution
Maximum cargo load
Cargo bed tailgate
Raising and lowering the cargo bed

Hydraulic outlet

Hydraulic outlet lever
Hydraulic outlet valve coupler connecting and disconnecting

Tires and wheels

Towing and transportation

Rear trailer hitch
Front trailer hitch
Winch Mount bracket
Transporting vehicle

Maintenance – service intervals and regular checks

Storage

Troubleshooting

Below are two different breakdowns of what parts may be available.

The first part is a breakdown of part by category, the second is a breakdown of parts by more specific motor or mechanical usage.

Some of these categories also applied to a range of Kubota Tractors, which are often used in conjunction with the Kubota RTV1140.

Category 1

Kubota RTV1140 parts – 3 Point Linkage / Drawbar/ Hitch

Lift Rod LH
Lift Rod RH
Lower link
PTO shaft protector
Stabiliser
Swinging drawbar
Top link
Top link bracket

Kubota RTV1140 parts – Air Conditioner

Air conditioning duct
Air conditioner hose
Compressor
Condenser
Dashboard air outlets
Heater hose
Inner air recirculation
Mode case

Accessories and Service parts

Brake parts

Brake
Brake pedal
Brake rod
Parking brake lever

Cabin Parts

Cab Bracket front
Cab Bracket rear
Cab Frame
Door LH
Doorlock LH
Door lock RH
Sender
Fender cover
Floor mat
Front glass
Hood rear
Inner roof
Near window
Rear view mirror
Seat
Side window
Toolbox

Canopy

Cargo and Storage Accessories

Chassis parts

Clutch parts

Center frame
Bevel gear
Clutch release fork
Clutch rod
Differential rear
Driveshaft
First shaft
Input shaft
PTO clutch
PTO clutch valve
PTO propellor shaft
PTO shaft
Rear axle case
Second shaft
Shift cover
Shuttle dear case
Shuttle shaft
Transmission case
Clutch
Clutch lever
Clutch pedal
Clutch housing

Cooling System parts

Radiator
Shutter
Fan
Reserve tank
Water pipe

Cylinder Head

Electrical system parts

Battery
Alternator
Dynamo
Dynamo and van
Light
Regulator and meter
Electrical wiring
Hazard light/tail light touch
Head light
Panel board/switch
Starter
Switch
Stop solenoid
Tail light
Working light
Switch/sensor

Engine parts

Accelerator lever
Air cleaner
Alternator
Camshaft and idle gear shaft
Cover
Crankcase
Cylinder head
Dipstick and guide
Exhaust manifold
Fan
Flywheel
Fuel camshaft
Gear case
Governor
Head cover
Idle apparatus
Injection pump
Inlet manifold
Lower gasket kit
Main bearing case
Muffler
Nozzle holder
Oil filter
Oil pump
Oil switch/thermometer
Piston and crankshaft
Speed control plate
Starter
Stop solenoid
Kubota kit
Valve and rocker arm
Water flange and thermostat
Water pump

Engine control parts

Filters and Maintenance

Frame Parts

Front axle parts

Differential gear shaft
Bevel gear case
Knuckle shaft
Engine support
Front axle
Front axle case
Front differential
Front differential case
Front drive shaft
Front frame
Subframe

Fuel Sytem Parts

Fuel pipe
Fuel filler
Sedimenter
Separator
Fuel filter
Fuel tank

Hood / Bonnet – ROPS Parts

Bonnet
Bonnet side
Center pillar
Floor sheet
Main frame
Shutter plate
Side cover
Fender
Front grille support
Lever guide
Manual holder
Panel frame
ROPS
Seat
Street support
Step
Step stay

Hitch and Drawbar

Drawbar and hitch
PTO shaft protector

Hydraulic system parts

3 point linkage
Control valve
Cylinder front cover
Draft control valve
Feedback lever
Hydraulic oil line
Hydraulic cylinder
Hydraulic pump
Lift arm
Position control lever
Top link bracket

Ignition Parts

Paint and Trim Parts

Pump Motor System

Control valve
3 point linkage
Feedback lever
Oil tank
Position control lever
PTO valve
Safety valve
Hydraulic control lever
Hydraulic cylinder
Hydraulic oil line/delivery
Hydraulic line/steering
Hydraulic piston/lift arm
Hydraulic pump
Hydraulic pump/component parts

Rear axle parts

Differential lock pedal
Rear axle
Rear differential
Rear wheel
Spiral bevel pinion

Rear PTO parts

Section part

Speed Change Lever

Differential lock shift fork
Frontwheel drive lever
Main gear shift fork
Main gear shift lever
PTO gear shift arm
PTO gear shift fork
PTO gear shift lever
PTO select lever
Range gear shift fork
Range gear shift lever
Speed control pedal

Steering parts

Steering controller
Steering cylinder/component parts
Steering handle
Manual steering
Steering linkage
Steering post
Tilt pedal

Kubota RTV1140 parts – Top Link / Top Link Bracket / PTO Protector –

Lift Rod
3 point linkage
Check chain
Hitch
Lower link
Mower rear link LH
Mower rear link RH
PTO protector
Top link
Top link bracket
Toys and Merchandise

Kubota RTV1140 parts – Transmission parts –

Clutch shaft/output shaft
Front wheel propeller shaft
Countershaft
Main shaft
PTO counter shaft
Reverse shaft
Forward idle shaft
GP idle shaft
HST one – cylinder block
HST two/arm
HST 3/port block cover
HST 4/oil cooler cover
HST fan cover
Mid PTO
Propeller shaft
PTO shaft
Rear gear shaft
Rear axle case
Rear differential
Transmission case

Wheel –

Category 2

Kubota RTV1140 Parts

Kubota RTV1140 parts – Filters and maintenance –

Air filter
Engine oil filter
Extended life antifreeze/coolant
Filter maintenance kit
Fuel filter – in line
High-performance agricultural/construction equipment grease
Hydraulic oil filter
Hydraulic suction oil filter
Lever action grease gun
Engine oil
Gear lubricant
Synthetic universal hydraulic fluid

Kubota RTV1140 parts – Cylinder head and component parts

Complete cylinder head
Exhaust valve guide
Inlet valve guide

Kubota RTV1140 parts – Gauges and Instruments

Temperature gauge

Kubota RTV1140 parts – Ignition parts

Glow plug
Starter switch and key

Kubota RTV1140 parts Transmission parts

HST Damper
Universal joint assembly

Kubota RTV1140 parts – Electrical

Alternator
Fuel shutoff solenoid
Hazard lamp
Headlight assembly
Headlight lens
Keys
Kubota battery
Oil pressure switch
Re-manufactured starter
Safety switch, seat
Starter assembly
Starter switch and keys
Tail lamp
Timer relay
Turn Signal Lamp

Kubota RTV1140 parts – Accessories and options

Mascot Mark
Steering wheel spinnerKubota RTV 900 parts
Trim

Kubota RTV1140 parts – Engine gaskets and gasket kits

Gasket kit – upper

Kubota RTV 1140 parts – Tires and wheels

Tire Repair Kit

Kubota RTV1140 parts – Operators compartment –

Lever guide – RH
Lever guide and cup holder LH

Kubota RTV1140 parts – Mower Deck Parts

Dial Cam

Kubota RTV1140 parts – Exhaust system parts

Exhaust manifold
Exhaust manifold gasket

Kubota RTV1140 parts – Cooling System Parts

Cooling fan
Fan belt
Lower radiator hose
Radiator
Radiator screen
Thermostat
Apart radiator hose
Water pump
Water pump gasket

Kubota RTV1140 parts – Fuel system parts

Fuel cap – gasoline
Fuel shutoff solenoid
Re-manufactured injection pump

Kubota RTV1140 parts – lubrication systems

Oil pump
Oil pump gaskets

Kubota RTV1140 parts -Steering and axles –

Steering wheel
Steering wheel cap

Kubota RTV1140 parts – 3 Point Hitch Parts –

3 Point category1 lower lift arm
Category one top link
Check chain assembly
Clevis assembly
lynch pin
Turnbuckle